Recent content by tosaman

  1. T

    2005 Navigator wiring diagram question

    I have two related problems with my 2005 Navigator. (1) the key will not come out of the ignition switch, and (2) the rear hatch will not open electronically (must do it manually). I'm pretty sure both of these problems are caused by bad connections in the larger junction connector that is...
  2. T

    '05 Navigator -- Air Suspension GONE!

    Sorry for the late reply. I finally took the car to the dealer for an oil change, etc. -- I asked them to update the computer so that the "suspension system off" light doesn't come on (i.e., set the computer as if the vehicle had a conventional spring suspension). They said no problem, but...
  3. T

    '05 Navigator -- Air Suspension GONE!

    Still plan to do it in next few weeks when I get an oil change. 04 and 05 should be the same as model didn't change between those two years. I'll still post results.
  4. T

    '05 Navigator -- Air Suspension GONE!

    I didn't mess with the fuse - just turned the system off with the switch at the back of the vehicle. Message comes on that the system is off every time I start the car, but will have the dealer reset the computer to show no airbags when I go in for a oil change in a few weeks. Then all I'll...
  5. T

    Rebuilt 5.4 Engine

    Threw one of the cam followers on my '05 Navigator driving home from Wisconsin last year -- happened just off the interstate in the middle of Illinois. Fortunately, there was a small Ford Lincoln dealer there who towed the car in and quickly found the problem. In any event, it meant that the...
  6. T

    '05 Navigator -- Air Suspension GONE!

    Will do. There are a variety of forum streams on the subject, but they read more like guys arguing over what wire to cut, etc. The Unity kit that I bought had the reference to having the dealer change the computer (even had instructions for how to do it). I'm going in for a dealer oil change...
  7. T

    '05 Navigator -- Air Suspension GONE!

    AGREE! Just the peace of mind is worth a lot in itself -- I'm no longer paranoid going on long trips, worrying that something will happen with the suspension. Noisy compressor?? The replacement that I bought from Rockauto was twice as loud as the OEM unit. But I had no trouble knowing when...
  8. T

    '05 Navigator -- Air Suspension GONE!

    My Nav has over 175K on it, and I've been dealing with air suspension problems for a while. Last year I replaced the front air bags struts with after-market units from Suncore (they're okay) - also new solenoids just to be safe. Then the compressor went out - replaced that this spring...
  9. T

    Front Airbag Strut Bolt Size

    Just a further follow-up... I found that the lower strut nut actually requires a deep 30M socket, given the length of the bolt through the tightened nut. The nut on the tie-rod end requires a deep 20M socket -- deep for the same reason. You might get by with 1-13/16" and a 13/16" SAE...
  10. T

    Front Airbag Strut Bolt Size

    Thanks for the quick reply. I think I can use a large crescent wrench to hold the bolt head, but will need to get the larger socket for the nut. Thanks also for the video. I've watched the separate video from Strutmasters several times, but they never mention the size of tools or hardware...
  11. T

    Front Airbag Strut Bolt Size

    I have new front airbag struts to install on my '05 Navigator. Noticed that my socket set was not big enough to handle the lower strut bolt and nut. Anyone know what size socket and box-end wrench that bolt/nut takes? Thanks.
  12. T

    Air Suspension Conversion

    I've got a 2005 Navigator that's starting to exhibit air suspension problems in cold weather. I've read a lot about converting the air bags to coil springs, but haven't seen much written in the forum on the subject. I'm wondering what is the best conversion kit to use. I see a lot of ads by...
  13. T

    2005 Navigator Center Shift Lever Console Removal

    The indicator light is out on the gear selector cover on my center shift lever console. Any thoughts on how to remove the chrome bezel. I was going to try and pry it off, but thought I'd check first in case I would break a clip or something. Thanks.
  14. 2005 Lincoln Navigator

    2005 Lincoln Navigator

    Engine Specifications: N/A Engine Misc.: N/A Turbocharger & Induction: N/A Fuel & Tuning: N/A Exhaust: N/A Drivetrain: N/A Weight reduction & transfer: N/A Suspension, wheels & tires: N/A Interior: N/A Exterior: N/A
  15. T

    Navigator intermediate steering shaft noise??

    I have a 2005 Navigator that has developed a "klunking" sound when I go over bumps. My first thoughts were worn bushings or a loose tailpipe hanger, however, my local Ford dealer said the only thing they could find was that the intermediate steering shaft was loose and wanted over $500 to fix...
Back
Top